Product ID:LUSTAQUIK ALKYD GLOSS EN VOC COMP BURNT WOOD, 165380
MSDS Date:05/25/1999
FSC:8010
NIIN:00N092248
Status Code:A
MSDS Number: CJQWF

KYANIZE PAINT

601 S HAVEN ST
BALTIMORE, MD 21224
US

Emergency Phone: 800-424-9300

Info Phone: 800-368-2076

Cage: 85520

KYANIZE PAINT

BALTIMORE, MD 21224 US

Telephone: 800-368-2076

Cage: 85520

SOLVENT NAPTHA (PETROLEUM), LIGHT AROMATIC; (AROMATIC

CAS: 64742-95-6

RTECS: WF3400000

BARIUM SULFATE

CAS: 7727-43-7

RTECS: CR0600000

OSHA PEL 15 MG/M3

ACGIH TLV: 10 MG/M3

STODDARD SOLVENT

CAS: 8052-41-3

RTECS: WJ8925000

OSHA PEL 2900 MG/M3;500 PPM

ACGIH TLV: 525 MG/M3;100 PPM

2-PROPOXYETHANOL

CAS: 2807-30-9

RTECS: KM2800000

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:REPORTS HAVE ASSOCIATED REPEATED AND
PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN AND NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING AND INHALING CONTE NTS MAY BE HARMFUL OR FATAL. ACUTE
OR REPEATED OVEREXPOSURE BY INHALING VAPORS MAY CAUSE RED BLOOD
CELL DAMAGE AND KIDNEY INJURY. INGESTION MAY CAUSE POSSIBLE KIDNEY
DAMAGE. THIS PRODUCT CAN BE ABSORB ED THROUGH SKIN CAUSING ORGAN
DAMAGE. BASED ON THE PRESENCE OF 2-PROPOXYETHANOL, THIS PRODUCT MAY
CAUSE MODERATE TO SEVERE EYE IRRITATION SEEN AS MARKED EXCESS
REDNESS AND SWELLING OF THE CONJUNCTIVA AND IS PRESUMED TO BE
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS NO REPORTED
CARCINOGENS OR SUSPECTED CARCINOGENS.
Effects of Overexposure:HLTH HAZ: MODERATELY TOXIC. BASED ON PRESENCE
OF AROMATIC NAPHTHA & STODDARD SOLVENT, THIS PRODUCT MAY CAUSE
NOSE, THROAT & EYE IRRITATION. BASED ON PRESENCE OF AROMATIC
NAPHTHA, HIGH VAPOR CONCENTRAT IONS MAY CAUSE CNS DEPRESSION; &
INGESTION OF THIS PRODUCT WILL CAUSE IRRITATION OF GI TRACT & MAY
CAUSE EFFECTS RESEMBLING THOSE FROM INHALATION OF VAPOR. STODDARD
SOLVENT IS A CNS DEPRESSANT & A MUC OUS MEMBRANE IRRITANT. SYMPTOMS
OF OVEREXPOSURE INCLUDE DIZZINESS, HEADACHE, INTOXICATION WITH
EUPHORIA LEADING TO UNCONSCIOUSNESS. BASED ON PRESENCE OF AROMATIC
NAPHTHA & 2-PROPOXYETHANOL, THIS PRODU CT MAY CAUSE SKIN
IRRITATION.

First Aid:EYES: FLUSH WITH LUKE WARM WATER FOR AT LEAST 15 MINUTES.
SEEK MD IMMEDIATELY. SKIN: FLUSH WASH WITH COPIOUS AMOUNTS OF LUKE
WARM WATER. REMOVE CONTAMINATED CLOTHING PROMPTLY. CONTACT MD
IMMEDIATELY. INHALATION: REMOVE EXPOSED INDIVIDUAL TO FRESH AIR.
RESTORE BREATHING IF REQUIRED. CONTACT MD IMMEDIATELY. INGESTION:
RINSE MOUTH IMMEDIATELY. GIVE EXPOSED INDIVIDUAL 6 TO 8 OUNCES OF
LIQUID. (NEVER G IVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.)
DO NOT INDUCE VOMITING UNLESS ADVISED BY A MD. CONTACT MD
IMMEDIATELY.

Flash Point Method:TCC
Flash Point:>40.C, 104.F
Lower Limits:0.5%
Upper Limits:7%
Extinguishing Media:THE NATIONAL FIRE PROTECTION ASSOCIATION CLASS B
EXTINGUISHER IS DESIGNED TO EXTINGUISH NFPA CLASS 1B FLAMMABLE
LIQUID FIRES.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . WATER SPRAY MAY BE INEFFECTIVE. WATER MAY BE USED TO
COOL CLOSED CONTAINERS TO PREVENT PRESSURE BUILDUP AND POSSIBLE
AUTOIGNITION OR EXPLO SION WHEN EXPOSED TO EXTREME HEAT. IF WATER
IS USED, FOG NOZZLES ARE PREFERABLE.
Unusual Fire/Explosion Hazard:FLAMMABILITY CLASSIFICATION:CLASS II. DOT
- COMBUST LIQ. KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM HEAT, ELEC
EQUIP, SPKS & OPEN FLAME. CLSD CNTNR MAY EXPLODE WHEN EXPOS TO
EXTREME HEAT. DO NOT APPLY TO HOT SURFS. NEVER USE WELDING/CUTTING
TORCH ON/NEAR CNTNR (EVEN EMPTY) BECAUSE PROD (EVEN RESIDUE) MAY
IGNITE (SUPP DATA)

Spill Release Procedures:STOP AND/OR CONTAIN DISCHARGE IF IT MAY BE
DONE SAFELY. KEEP ALL SOURCES OF IGNITION AWAY. VENTILATE AREA OF
SPILL. USE NON-SPARKING TOOLS FOR CLEANUP. COVER WITH INERT
MATERIAL TO REDUCE FUMES. KEEP OUT OF DRAINS, SEWERS OR WATERWAYS.
CONTACT FIRE AUTHORITIES. NOTIFY LOCAL HEALTH AND POLLUTION CONTROL
AGENCIES. CALL SPILL RESPONSE TEAMS IF LARGE SPILL.

Handling and Storage Precautions:DO NOT BREATHE VAPORS OR SPRAY MIST.
AVOID CONTACT WITH EYES. KEEP FROM FREEZING. DO NOT STORE ABOVE
120F. DO NOT TAKE INTERNALLY. CLOSE CONTAINER AFTER EACH USE. KEEP
OUT OF REACH OF CHILDREN!
Other Precautions:THIS PRODUCT CONTAINS PIGMENTS WHICH MAY BECOME A
DUST NUISANCE WHEN REMOVED BY ABRASIVE BLASTING, SANDING OR
GRINDING.

Respiratory Protection:WEAR APPROP, PROPERLY FITTED, NIOSH APPRVD RESP
DURING & AFTER APPLICATION UNLESS AIR MONITORING DEMONSTRATES
VAP/MIST LEVELS ARE BELOW APPLIC LIMS. FOLLOW RESP MFR'S DIRECTIONS
FOR RESP USE. IN OUTDO OR/OPEN AREAS USE NIOSH APPRVD MECH FILTER
RESP TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY DURING SPRAY
APPLICATION. IN RESTRICTED VENT AREAS (OTHER INFO)
Ventilation:USE VENT AS REQD TO CONTROL VAP CONCS. AVOID PRLNG/RPTD
BRTHG OF VAPS. IF EXPOS EXCEEDS TLV, USE NIOSH APPRVD RESP TO PVNT
OVEREXP. PROVIDE GEN (OTHER INFO)
Protective Gloves:RESISTANT GLOVES, SUCH AS NATURAL RUBBER, NEOPRENE,
BUNA N OR NITRILE.
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA . AN APRON SHOULD BE WORN TO AVOID SKIN CONTACT.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING IMMEDIATELY AND DO
NOT WEAR IT UNTIL IT HAS BEEN PROPERLY LAUNDERED.
Supplemental Safety and Health
PHYSICAL/CHEM DATA: WT/GAL:9.1. % VOLAT BY WT:33.12. VOC:3.023. --
EXPLO HAZ: EXPLOSIVELY. CNTNRS EXPOS TO INTENSE HEAT FROM FIRES
SHOULD BE COOLED W/WATER TO PVNT VAP PRESS BUILDUP WHICH COULD RSLT
I N CNTNR RUPTURE. HMIS RATINGS: HLTH - 2; FLAMMABILITY - 2;
REACTIVITY - 0.

Boiling Pt:>148.9C, 300.F
B.P. Text:300F - 388F
Vapor Pres:3 MMHG @ 68F
Vapor Density:HVR/AIR
Volatile Org Content %:3
Spec Gravity:1.09
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Percent Volatiles by Volume:45.75

Stability Indicator/Materials to Avoid:YES
THIS PRODUCT IS INCOMPATIBLE WITH STRONG ACIDS.
Stability Condition to Avoid:AVOID EXPOSURE TO SPARKS, OPEN FLAME, HOT
SURFACES AND ALL SOURCES OF HEAT AND IGNITION.
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION AS IN WELDING. FUMES MAY CONTAIN CARBON
MONOXIDE, CARBON DIOXIDE AND OXIDES OF NITROGEN
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:DO NOT FLUSH TO SEWER, WATERSHED OR WATERWAY.
DISPOSE OF I/A/W LOCAL, STATE AND FEDERAL REGULATIONS. DO NOT
INCINERATE CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:ENVIRON FATE, ENVIRON EFT: NO DATA AVAIL. TOXICITY INFO:
1994. FORMALDEHYDE: LC50=0.59 MG/L (RAT) RESP SENSITIZER, RTECS
1985, DOC TLV'S 1991. INGEST: ORAL LD50 >500 MG/KG (RAT), 197-2198.
EYES: NO DA TA AVAIL FOR FORMULATION. ACRYLAMIDE: MOD TO SEV IRRIT
(RABBIT), DOC TLV'S 1986, GOSSELIN 1984, RTECS 1983. FORMALDEHYDE:
SEV IRRITANT, RTECS 1985. NMA: MILD TO MOD IRRITANT. NTP TRS 352.
DEGDA: CORR; SEV IRRITATING, PATTY'S 1194, J TOXICOL ENVIRON HLTH
19:149 1986. TREDGA: CORR, J TOXICOL ENVIRON HLTH 19:149 1986.
ACUTE EFTS FROM OVEREXP: LONG RANGER MAY BE HARMFUL BY INGEST.
(TRANSPORTATION INFO )

Transport Information:U.S. DOT/ICAO/IATA/CANADA (TDG): NON HAZ.
ECOLOGICAL INFO: ACRYLAMIDES ARE READILY ABSORBED THRU SKIN & BY
INHAL & ARE IRRITATING TO SKIN, EYES & RESP TRACT. FORMALDEHYDE
CAUSES IRRIT OF EYES, NOSE, T HROAT & RESP TRACT AT LOW CONCS (<1
PPM). DFCLTY IN BRTHG MAY OCCUR AT 10-20 PPM, W/SERIOUS INJURY TO
RESP TRACT AT 50 PPM. EXPOS TO FORMALDEHYDE MAY PRDCE ALLERGIC RESP
EFTS, INCL ASTHMA, IN SENSITIZ ED INDIVIDUALS. DIETHYLENE GLYCOL
DIACRYLATE IS CORR TO EYES (CAUSES SEV CORNEAL DMG) & SKIN, & HAS
BEEN REPORTED TO BE A SKIN SENSITIZER. TETRAETHYLENE GLYCOL
DIACRYLATE IS MOD IRRITATING TO SKIN W/A CUTE EXPOS & CORR TO EYES.
(SARA REGS)

SARA Title III Information:THIS PRODUCT CONTAINS A TOXIC CHEMICAL OR
CHEMICALS SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF
THE EMERGENCY PLANNING AND COMMUNITY RIGHT-TO-KNOW ACT OF 1986 AND
OF 40 CFR 372.
State Regulatory Information: